在線咨詢
官方二維碼
當前位置：
2023.09.14
燃?xì)獍l(fā)電機組啟動分析會出現哪些故障？
檢查電源或其它電器件可能的原因主要有：
The main possible reasons for checking power supplies or other electrical components are:
蓄電池存電不足，發動機運轉無力或轉速低；
Insufficient battery storage, weak engine operation or low speed;
起動吸鐵開關打滑，碳刷接觸不良；
The starting iron suction switch is slipping and the carbon brush has poor contact;
檢查各插接件是否松動或被侵蝕；
Check whether each connector is loose or corroded;
導線過長、過細，導致電阻過大，產生電壓降；
The wire is too long or too thin, resulting in excessive resistance and voltage drop;
起動機接線不正確。
The starter wiring is incorrect.
檢查燃料閥或者節氣門是否工作
Check if the fuel valve or throttle valve is working
檢查點火系統，火花塞是否點火正常
Check the ignition system and whether the spark plug ignites normally
檢查燃?xì)夤┙o
Check gas supply
可能的原因主要有：
The main possible reasons are:
燃?xì)夤┙o不足或管路不通，導致沒有足夠的燃?xì)猓?/div>
Insufficient gas supply or blocked pipelines, resulting in insufficient gas supply;
檢查燃?xì)馐欠駢毫^(guò)低，供氣不足，空氣未排凈；
Check if the gas pressure is too low, the gas supply is insufficient, and the air is not completely discharged;
檢查燃?xì)馐欠駢毫^(guò)高，導致進氣量過大
Check if the gas pressure is too high, causing excessive intake volume
檢查燃?xì)鉄嶂担欠穹蠁?dòng)要求，熱值過低時，機組啟動困難或無法啟動
Check the calorific value of the gas to see if it meets the start-up requirements. If the calorific value is too low, it may be difficult or impossible for the unit to start
點火時間是否正確；
6停車手柄未復位。
6停車手柄未復位。
Is the ignition time correct< The parking handle has not been reset.
考慮進氣量不足的可能
問題主要在于：
問題主要在于：
The main problem with considering the possibility of insufficient intake volume is:
進氣受堵，這主要為空濾器積塵過多或受潮所至；
The intake is blocked, mainly due to excessive dust accumulation or moisture in the air filter;
進排氣門間隙過大或過小，發動機會有異常響聲；
If the clearance between the intake and exhaust valves is too large or too small, the engine will make abnormal noises;
排氣受堵，可能為進氣壓縮力不足方面。
The exhaust is blocked, which may be due to insufficient compression of the intake air pressure.